Field of the Invention
The present invention relates to devices for monitoring and testing electrical power supply devices, and more particularly to and for a standard 3-Wire 120 volt AC electrical outlet, which assures the user that the outlet has been wired properly and has acceptable grounding properties.
Background of the Invention
For many years it has been known that the safety ground in AC outlets in important, this ground connection will shunt current which can appear on the enclosure of the tool or appliance, due to a defect in insulation, harmlessly to ground. If the enclosure were not properly grounded and the hot wiring of the power tool were to short to the case, the user could suffer injury or death if he or she were standing on a surface which had a path to earth ground or were touching a surface which was connected to earth ground. If the tool being used were to develop such a fault and the outlet wiring was proper, a large amount of current would flow from the HOT wire of the AC outlet through the tool and back through the safety ground of the AC outlet, thus exceeding the current rating of the circuit breaker or fuse which protects the wiring and tripping the breaker or blowing the fuse. It now becomes apparent that the total resistance of the HOT and SAFETY GROUND must have a value low enough to allow a current exceeding the rating of the circuit breaker or fuse to flow thus insuring that the power to the circuit will be interrupted due to such a fault.
Most 120 VAC circuit breakers have a rating of 20 amps. Using Ohms Law only, we find that the total resistance of the wiring from the main panel to the AC outlet and the connection from the AC outlet to earth ground must not exceed 6 ohms. If this total resistance is greater than 6 ohms, the breaker may not trip during a fault and a dangerous condition in terms of fire hazard or shock will result. The potential for poor electrical connections to earth ground are the most prevalent since these connections are usually made through the metallic conduit which carries the wiring. This conduit typically has many couplings and connections through junction boxes between the AC outlets and the connection to earth ground which usually terminates at the power panel. In addition to faulty assembly of these ground returns, the connections over time may loosen or corrode causing the resistance to increase.
As shown in the example above, the total resistance of the circuit must not be greater than 6 ohms. The most popular outlet tester on the market uses neon bulbs to indicate AC outlet miswires, these lamps requiring only 1 or 2 milliamperes to light or turn on. A faulty ground connection having a resistance as high as 120,000 ohms will light the lamp in this type of tester and the user will assume the outlet is safe to use when it is not.
It becomes apparent that more than 1 or 2 milliamperes is required to properly exercise these wiring connections, but a problem arises with ground fault interrupter outlets. These outlets will trip if more than 3 milliamperes of current flow from the HOT WIRE and through the ground return of the outlet. Thus, a tester which causes more than 3 milliamperes to flow through these wires during testing is not usable since the interrupter would trip every time it was tested. Applicant has found that the solution to this problem is to draw high current short duration pulses, currents exceeding 20 amps may be drawn from the HOT WIRE to EARTH GROUND through the outlet without tripping the interrupter, if the duration is short enough. A total duration of 3 to 5 microseconds with peak currents of 20 amps or more will not trip these interrupters and the resistance of the wiring can now be determined by detecting the amplitude of the current pulses. If the total resistance of the circuit is lower than a predetermined limit, the peak current will be high enough to trigger a light indicating the outlet is safe to use.
In view of that set forth above and other known deficiencies of the prior art for testing not only that an AC outlet is properly wired but also to determine any defect in the connection of the hot, neutral and ground wire connections, and further to detect a defective ground, the present invention provides the following advantages.
It is an object of the invention to provide a tester unit for detecting and indicating the occurrence of proper wiring of a tested AC outlet, a defective ground, an open Neutral, reversed Hot and Neutral connections, a connection wherein "Hot on Neutral with open Neutral" occurs, and an open Hot connection.
It is another object of the invention to assure the user that the AC outlet has been wired properly and the total resistance of the Hot wire and the Ground return is below 6 ohms.
Various other objects and advantages of the present invention will be made known upon reading and understanding the detailed description of the invention which follows.
Summary of the Invention
The foregoing objects of the invention are achieved in an AC POWER OUTLET GROUND INTEGRITY AND WIRING TESTER UNIT DEVICE AND CIRCUIT having three LED's "Red" "Green" and "Yellow", which LED's are actuated or energized to indicate any occurrence of proper and improper wiring connections of the Hot, Neutral, and Ground wires of the AC outlet, such being accomplished by operative circuitry including three relaxation oscillator circuits, each incorporating therein a LED indicator device to indicate the occurrence of a specific wiring condition, with all three of these oscillator circuits being contained in the tester unit/device and being connected between any of the Hot, Ground, and Neutral wiring connections of an AC outlet when the tester unit is plugged into the outlet.
Brief Description of the Drawing
The novel features of the invention are set forth in the appended claims. The invention itself will be described with reference to the illustrative preferred embodiment depicted in the accompanying FIG. 1 drawing.
Detailed Description of the Preferred Embodiment
With reference to FIG. 1, there is depicted an electrical AC outlet monitoring and testing circuit device 10 that includes a first indicator light, a second indicator light, and a third indicator light. In a preferred embodiment of tester 10, the first indicator light is a Green LED D4, the second indicator light is a Red LED D2, and the third indicator light is a Yellow LED D6. Only the Green LED D4 will light or flash when the AC outlet is wired correctly and a total resistance, which is defined as the arithmetic sum of the resistances of the HOT WIRE and of the Ground return, is below a predetermined ohmic resistance limit. As discussed in the "Background" section, safety considerations dictate that for testing a standard 120 volt AC outlet, the predetermined ohmic resistance limit be set at about 6 ohms for a corresponding 20 (120 volts/6.OMEGA.) amperage current breaker. However, by using Ohm's Law this predetermined ohmic resistance limit may be set to accommodate any amperage circuit breaker operating on any voltage including those other than 120 volts. Each of the LED's, when lit or energized, will flash briefly several times a second. The chart below shows the various faults and flashing light combinations for wiring faults that may be detected by tester 10.
The invention circuit simplicity, as shown in FIG. 1, will allow it to fit into a small hand-held, plug-in type enclosure, not shown. It is also self-powered from the AC line (outlet). Power is supplied from the Hot AC wire line 12 through Fuse F1 through Diode D1 and through current limiting resistor R2 to capacitor C1 via circuit line 13. The voltage capacitor C1 will charge to is limited to 15 volts which is controlled by zener diode D3 which is connected in series with resistor R4 to circuit common CC which is connected to the Neutral wire line 16 of the AC outlet 18 under test. The 15 volts appearing at the junction R2, D3, and C1 is connected to a current limiting resistor R1 which is connected to LED D2 which is connected to the anode of SCR Q1. The cathode of Q1 is connected to circuit common CC and the gate of Q1 is connected to the junction of D3 and R4. When the unit is plugged into the AC power outlet and power is applied to the invention circuit, the voltage across C1 will cause current to flow through zener diode D3 and resistor R4. The current through R4 will cause a voltage exceeding 0.6 volts to be developed across it and this voltage will then cause a current to flow into the gate of SCR Q1 which will cause Q1 to conduct current and light or energize LED D2. LED D2 will remain on only briefly since the energy stored in capacitor C1 will be rapidly depleted and the current through Q1 will fall below its holding current. When Q1 turns off, due to the lack of sufficient holding current, the voltage across capacitor C1 will again begin to rise and the cycle will repeat. The circuit described so far is a complete self-contained first relaxation oscillator which will flash or light the LED D2 at a rate determined by the applied line voltage and the predetermined values of R2, D3, R4 and C1. The operation of this first relaxation oscillator will be inhibited if the voltage across capacitor C1 is kept below the zener voltage of D3. This brings us to the second part of the circuit: Resistor R3, LED D4, and SCR Q2, which are connected in series with each other between R2 and CC. This series circuit is connected across or in parallel with capacitor C1. If Q2 is triggered before the voltage across C1 reaches 15 volts, then LED D4 will flash (be lit or energized intermittently) rather than LED D2. Q2 is triggered by the action of a second relaxation oscillator circuit comprised of diode D1, SIDAC Q3, and the parallel combination of resistor R5 and capacitor C2 which are coupled to the ground connection of the AC outlet 18 by way of a wire loop 19 around coil L1, and circuit line 20. This second relaxation oscillator will produce pulses at a predetermined rate two times that of the first relaxation oscillator mentioned above.
When power is applied to the tester 10, upon plug-in to outlet 18, capacitor C2 has no voltage across it. The voltage necessary to cause SIDAC Q3 to breakdown is 120 volts. Only the positive half cycles of the AC line voltage are passed by diode D1 and when the positive half of the line cycle reaches 120 volts, breakover device Q3 will become conductive causing capacitor C2 to rapidly charge in about 4 microseconds. At this time, the current through Q3 will fall below its holding current and Q3 will turn off. C2 will now begin to discharge through resistor R5 and when the voltage across C2 has fallen to a voltage low enough to allow 120 volts to again appear across Q3, the cycle will be repeated again. With the component values shown in FIG. 1, Q3 will fire approximately six (6) times a second. Basically, the peak current that will flow is determined by the forward drop of diode D1, Q3 and the ESR of capacitor C2. Since these drops are very low, the main limit to the current flowing is the resistance of the AC wiring in outlet 18. The current flowing through the loop 19 around coil L1 induces a voltage in coil L1 which voltage is applied to the gate of Q2 "via circuit line 21" which has a variable resistor connected from the gate of Q2 to circuit common CC. This resistor R6 acts as a current shunt which controls the sensitivity of Q2, and R6 is set to prevent Q2 from triggering if the peak current pulse flowing in the loop 19 around coil L1 is below a predetermined level. If Q2 is not triggered due to insufficient current being sensed by coil L1, then the prior described first relaxation oscillator will become operative and the Red LED D2 will start to flash indicating a defective ground.
Open Neutral Wire Condition: This brings us to the third relaxation oscillator circuit which is configured like the first relaxation oscillator circuit except that it is connected across the Neutral and Ground connections of the AC outlet under test, via wire lines 14 and 16, and comprises: D5, R7, R8, C3, D7, R9, Q4, and LED D6 (Yellow). When the AC outlet is wired properly, no potential difference exists across these two points (Neutral and Ground) and this third oscillator is inoperative. If the Neutral wire is open, the current flowing from the circuit common CC for the first oscillator must now flow through the third relaxation oscillator via D5 et al., to reach ground potential. Thus, the first oscillator and the third oscillator are placed in series across the outlets' Hot and Ground lines. Since the second relaxation oscillator is operational causing the first relaxation oscillator to be inactive, both the Green and Yellow LED's D4 and D6 will now flash or be lit at a predetermined rate.
Reversed Hot and Neutral wires condition: Upon detection of this condition, no potential difference will exist across the second oscillator, and Q3 will not fire or conduct which will allow the Red LED D2 to flash or be lit at a predetermined rate. The fact that Neutral is now Hot and Hot is now Neutral makes no difference to the first oscillator. The Yellow LED D6 will also flash at a pre-set rate since the third oscillator will now be connected across 120 volts AC and because the Neutral wire will now be Hot.
Hot On Neutral With Open Neutral Condition: Only the Yellow LED D6 will light or flash at a pre-set rate since only the third oscillator circuit will have 120 volts across it. Here it is assumed that the Hot part/wire of the AC outlet is open and no wire is connected to it.
No Lights Flashing Condition: For this to occur, the AC outlet 18 would have to be "dead" (no Hot connection) or both the Neutral and Ground connections would have to be "open" at the same time.
It can now be seen from the foregoing disclosure that the present invention provides numerous advantages over the known prior art, and that the numerous fault detection operations of the invention unit are accomplished via a single self-contained, small hand-held, plug-in type, enclosure device which is powered from the AC line contained in the AC outlet under test.
With respect with the circuit components mentioned above and shown in FIG. 1: All resistor values are in ohms (.+-.5%) and 1/4 watt unless otherwise noted, and all capacitors are in ufd. (.+-.10%).
Although the invention has been described with reference to a preferred embodiment, this description is not meant to be construed in a limiting sense. Various modifications of the disclosed embodiment, as well as alternative embodiments of the invention, will become apparent to persons of skill in the art upon reference to the description of the invention. It is therefore contemplated that the appended claims will cover such modifications that fall within the true scope of the invention.